zxr250 cutting out

mohawk miss · Post by **mohawk miss** » Fri Nov 03, 2006 10:02 am

I had a car that wouldnt start if it was hot, it was something to do with the charging system on the battery. Battery was always normal when tested with a voltmeter. It *did* take nearly 2 years to track down the exact problem....

Dont know if the systems are the same on a bike.

Zombie · Post by **Zombie** » Fri Nov 03, 2006 2:55 pm

Ditto on my zzr

Race Rep seem to be at a loss too.

Burky · Post by **Burky** » Fri Nov 03, 2006 3:19 pm

The ignition on a car how different are they to d bike??
Reason is the old cortina i had, had a loose wire in the distributor as soon as the thing would warm up the wire would loose contact car would shut down (sound similar to what is happening here). After 4days of looking at wiring i found it. If they are similar i would start there if it's not fuel. But don't just look at the conection give it a small play to insure it is conected. Mine looked like it was conected but it pritty much wasn't.

SuN~e · Post by **SuN~e** » Fri Nov 03, 2006 3:28 pm

hmmm, i dunno anything about electricals.
i jsut dropped it off at a mechs in chipping norton to have a look at it. hopefully everything goes well.
thanx to chrissie (fallen angel) for the trailer.

plane · Post by **plane** » Fri Nov 03, 2006 5:15 pm

It will be the fact that the vaccuum hose is disconnected.

Are you running the bike with the fuel tap in the "Prime" position? That should be the only way that a vaccuum operated fuel tap can flow freely. But that may not supply fuel at a fast enough rate to keep up with the demand of a 18,000 rpm redline. Hence the float bowls will drain and the bike stops.

Re-connect the vaccuum hose and take it for a run.

Cheers,
Pete

SuN~e · Post by **SuN~e** » Sat Nov 11, 2006 9:48 am

so i brought it over to a mechanic to take a look,
ended up LOOKING at it for 3 hours and ended up fixing wateva the problem was for anopther hour
=\
he said it was something to do with the carbies
*sigh*
got chargeed a fair bit but hey...sounds better and runs better

Gosling1 · Post by **Gosling1** » Sat Nov 11, 2006 10:23 am

SuN~e wrote:...he said it was something to do with the carbies...

Did he say *what* exactly ?? sounds like they may have charged you for smoko, lunch, and 10 minutes actually *fixing* the problem

SuN~e · Post by **SuN~e** » Sun Nov 12, 2006 7:27 pm

don't know what the exact problem was,
he just wrote down a bunch of mumbo jumbo on wat he did,
atleast everything is fine now except for the fact that i am broke for awhile
=\

Gosling1 · Post by **Gosling1** » Sun Nov 12, 2006 8:23 pm

mmmmm, well as long as you are happy with the result, that is the important thing......